OK, I have factory cab lamps inspected; they looked fine, but I installed all brand new OE lamps.
I was aware of the water leak from the CHMSL and sealed it with butyl tape, but I just ordered a brand new OE lamp (part number change from a revision) and not sure what changed, but I installed the new lamp. I am getting a tiny bit of dampness inside the rear under-seat storage bin on the pass side; the rest is all dry.
It's a minimal amount, with no standing water, just damp.
I have a cardboard box in there with some special tools to service Warn-free wheeling hubs if I am out on the road and it degraded from being damp, so now I'm using a small shotgun plastic ammo from Plano for those tools.
The liner in the storage pocket is rubberized, so the water is coming in from the top.
I have a satellite antenna on that side, suppose it could be the rear power sliding rear window.
The CHMSL is a known issue; I think I have it covered.
TSBss showed some seam leaks and GPS antenna, but only in the the1500s, they showed the CHMSL for 2500/3500, but I think I have it covered.
Does anyone else have this issue? I may run the heater at full speed on fresh air, pressurize the cab and use the soap spray around suspected areas.
Thanks for listening.
Bookmarks